无锡科达脚手架厂【官网】主营:脚手架、移动脚手架、门式脚手架、梯形脚手架

无锡科达脚手架厂

示例图片三
网站首页 > 新闻资讯 > 时事新闻

环氧地坪漆施工环境的几大要素及工艺流程

2019-02-08 16:07:49 无锡科达脚手架厂 阅读

施工环境是指施工时周围环境的气象条件及卫生情况(污染物)。它在环氧地坪漆涂料的干燥与成膜过程中起重要的作用,对环氧地坪漆涂膜的黏度和地坪漆涂层的质量有很大的影响。环氧地坪漆施工环境的几大要素:1、自然界中的风力同样也是影响地坪漆施工质量的因素之一,施工时既要保证地坪漆施工现场的通风,但风力又不能过大。这是因为风力过大会分别加速地坪漆涂料中溶剂和水分的蒸发,使地坪漆工程涂料成膜不佳,此外还会降低空气的洁净度,使地坪漆工程涂层沾上杂质。所以,当风力级别>4级的大风天气,应停止地坪漆涂料的施工。2、光照也是影响地坪漆涂装效果的重要因素之一,地坪漆涂料在贮存和运输过程中要防止暴晒,在施工过程中要防止阳光直射。尤其在炎热高温的夏季,阳光直射下的被涂饰的地坪漆基层表面温度过高,会使其脱水或脱溶剂速度过快,使成膜的效果不佳,从而严重影响地坪漆涂层的质量。3、同时也应考虑污染物质的影响。地坪漆施工现场周围环境中,如有工厂或汽车排出的大量的废气,如SO2,H2S等腐蚀性气体,以及周围环境中产生飞扬的灰尘,都将对地坪漆的施工质量造成影响。因此当发现施工现场有特殊的气味或飞扬的尘土,应暂停施工,当发现污染物质已经沽污部分涂层,应及时清洗干净。

Construction environment refers to the meteorological conditions and hygienic conditions (pollutants) of the surrounding environment during construction. It plays an important role in the drying and film-forming process of floor coatings, and has a great influence on the viscosity and quality of floor coatings. Several key elements of the construction environment of epoxy floor paint: 1. Wind in nature is also one of the factors affecting the construction quality of floor paint. It is necessary to ensure the ventilation at the construction site, but the wind force should not be too large. This is because excessive wind speed up the evaporation of solvent and water in floor paint, which makes the film formation of floor paint poor. In addition, it also reduces the cleanliness of the air and makes the floor paint coatings contaminated with impurities. Therefore, when the wind level > 4 wind weather, should stop the floor paint construction. 2. Illumination is also one of the important factors affecting the painting effect of floor paint. Floor paint should be protected from sunshine during storage and transportation, and from direct sunlight during construction. Especially in hot and high temperature summer, the surface temperature of the coated floor paint under direct sunlight is too high, which will make its dehydration or solvent removal speed too fast, so that the effect of film formation is not good, thus seriously affecting the quality of the floor paint coating. 3. The influence of pollutants should also be considered. Surrounding environment of floor paint construction site, if there is a large amount of waste gas from factories or automobiles, such as SO2, H2S and other corrosive gases, as well as flying dust in the surrounding environment, will affect the construction quality of floor paint. Therefore, when special smells or flying dust are found in the construction site, construction should be suspended. When it is found that contaminants have already polluted part of the coating, it should be cleaned in time. 

只有严格把控地坪漆施工环境,处理好地坪漆施工外在与内在的环境因素, 才能做好高品质、高质量的环氧地坪

Only by strictly controlling the construction environment of floor paint and dealing with the external and internal environmental factors of floor paint construction, can we do a good job of high quality epoxy floor.

产品说明:环氧地坪漆为双组份常温固化自干型油漆,组份一是由环氧树脂、颜填料、溶剂组成,组份二是固化剂,是目前应用比较广泛的地坪油漆涂料品种。当涂刷在水泥地面时需先用封闭底漆,方可涂刷地坪。

Product Description: Epoxy floor paint is a two-component room temperature curable self-drying paint, which consists of epoxy resin, pigments and fillers, solvents, and curing agent. It is a widely used floor paint variety at present. When painting on the cement floor, it is necessary to use a closed primer before painting the floor.

主要特性:环氧地坪漆常温干燥,干后漆膜硬度高、附着力好,涂料与水泥、木材、金属表面的粘结力强,涂层具有良好的耐磨、抗冲击性能。

Main characteristics: Epoxy floor paint is dried at room temperature. After drying, the film has high hardness and good adhesion. The coating has strong adhesion with cement, wood and metal surface. The coating has good wear resistance and impact resistance.

主要用途:环氧地坪漆是一种高强度、耐磨损、美观的地板,具有无接缝、质地坚实、耐药品性佳、防腐、防尘、保养方便、维护费用低廉等优点。可根据不同的用途要求设计多种方案,如薄层涂装、1-5mm厚的自流平地面、防滑耐磨涂装、砂浆型涂装、防静电、防腐蚀涂装等。适用于各种场地,如:厂房、机房、仓库、实验室、病房、手术室、车间等。

Main Applications: Epoxy floor paint is a kind of high strength, wear-resistant, beautiful floor, with seamless, solid texture, good resistance, anti-corrosion, dust-proof, easy maintenance, low maintenance costs and other advantages. Various schemes can be designed according to different application requirements, such as thin coating, 1-5mm thick self-leveling floor, anti-skid and wear-resistant coating, mortar coating, anti-static, anti-corrosion coating, etc. Suitable for all kinds of venues, such as: workshop, machine room, warehouse, laboratory, ward, operating room, workshop, etc.



标签:   脚手架 环氧地坪 移动脚手架 脚手架厂家 梯形脚手架 门式脚手架 梯形脚手架