无锡科达脚手架厂【官网】主营:脚手架、移动脚手架、门式脚手架、梯形脚手架

无锡科达脚手架厂

示例图片三
网站首页 > 新闻资讯 > 时事新闻

怎么降低天然气热风炉的气耗?只需做到这几点!

2018-11-29 09:27:44 无锡科达脚手架厂 阅读

燃气热风炉成都收账使用领域比较广泛,它主要是可以利用一定成都找人公司间接传递技术进行运行成都收账,它主要是以干净收账空气为介质,提供直接热源,而这个过程中,难免就会出现耗气量,降低天然气热风炉成都找人公司气耗就意味着降低生产成本,那么该怎么降低天然气热风炉的气耗呢?

Gas-fired hot-blast stove is widely used in many fields. It can be operated mainly by some indirect transfer technology. It mainly uses clean air as medium to provide direct heat source. In this process, gas consumption will inevitably occur. Reducing gas consumption of gas-fired hot-blast stove means reducing production cost. How to reduce the gas consumption of natural gas hot stove? 只需做到这几点:

Just do these things:

1、必须使用规定气种,如液化气机型必须使用液化气,天然气机型必须使用天然气,多气种机型更换气种前必须对设备进行必要的调试,以保证设备的安全及正常使用,且不得使用设备规定之外的其它可燃气体,以免发生危险。

1. The specified types of gas must be used. For example, liquefied gas must be used for liquefied gas models. Natural gas must be used for natural gas models. Before replacing various types of gas models, the equipment must be debugged to ensure the safety and normal use of the equipment, and other combustible gases other than those specified in the equipment shall not be used to avoid danger. 。

2、对于用气量较大的大型天然气热风炉必须加装燃气过滤装置,避免燃气管道中的渣滓进入燃烧机,损坏燃烧组件,并对过滤装置进行定期清理。

2. For large natural gas hot-blast stoves with large gas consumption, gas filtering devices must be installed to avoid the sludge from the gas pipeline entering the burner, damage the combustion components, and regularly clean up the filter devices.

3、如若移动式机型使用天然气,并采用硬式管道连接,为避免发生危险,必须对设备进行固定处理,以避免设备在非人为意愿下的意外移动对燃气管道造成损伤。

3. If the mobile type uses natural gas and adopts hard pipeline connection, in order to avoid danger, it is necessary to fix the equipment so as to avoid the damage to the gas pipeline caused by the unexpected movement of the equipment without human intention.

4、气体压力及燃气质量必须达到使用标准,否则有可能造成点火失败或长期使用对设备造成伤害等,且液化气瓶不要置于高温环境中,否则有可能发生爆炸危险。

4. Gas pressure and gas quality must meet the use standard. Otherwise, it may cause ignition failure or damage to equipment caused by long-term use, and liquefied gas cylinders should not be placed in high temperature environment, otherwise explosion risk may occur.

5、对于连接天然气设备的送气管道,必须使用符合规定的高标准管道及设备规定口径的管道,否则有可能造成供气不畅造成的无法点火成功或其它故障。

5. For gas pipelines connected with natural gas equipment, high-standard pipelines and pipelines of specified caliber must be used, otherwise it may cause failure of ignition or other faults caused by poor gas supply.

而且这几点也需要格外注意:

And these points need special attention:

1、设备出风口温度很高,尤其是燃烧室内部达到高温800摄氏度,所以出风口前部2米处禁止站人及设备前部10米处禁止堆放易燃物品。设备后部要保持与物体最少50cm的距离,保证进风通畅。

1. The temperature of the air outlet of the equipment is very high, especially the high temperature of 800 degrees Celsius in the combustion chamber. Therefore, it is forbidden to stack inflammable articles at the front 2 meters of the air outlet and at the front 10 meters of the equipment. The rear part of the equipment should be kept at least 50 cm away from the object to ensure smooth air intake.

2、热风炉属于危险品,禁止儿童、残障者、智障者、精神障碍者接触,设备的管理者需对设备进行一定程度的培训方可安全使用设备。

2. Hot stoves are dangerous goods. Children, the disabled, the mentally handicapped and the mentally handicapped are forbidden to contact. The managers of equipment need to train the equipment to a certain extent in order to use the equipment safely.

3、对于直燃式设备需要定时对室内进行通风换气,以保证室内氧气的充足供应及废气的排出,否则严重情况下有可能会造成缺氧窒息、一氧化碳中毒等现象。

3. For direct-fired equipment, regular ventilation and ventilation are needed to ensure adequate supply of indoor oxygen and exhaust gas discharge. Otherwise, it may cause hypoxia, asphyxia, carbon monoxide poisoning and other phenomena in serious cases.

4、对于间燃式设备必须将烟道引至室内,或将设备置于室外,否则将会造成室内空气的污染情况,及一氧化碳中毒状况。

4. For intercombustion equipment, the flue must be led indoors or placed outdoors. Otherwise, it will cause indoor air pollution and carbon monoxide poisoning.

5、不得私自对设备进行拆除、改造、维修等行为,除非在厂家授权并进行指导的情况下进行,否则将有可能发生危险,厂家将不负责任何后果。

5. It is forbidden to dismantle, renovate and repair the equipment privately. Unless it is carried out under the authorization and guidance of the manufacturer, it will be dangerous and the manufacturer will not be responsible for any consequences.



标签:  脚手架 热风炉 梯形脚手架 脚手架 脚手架厂家 移动脚手架